Safe Canning Amid Canning Supply Shortages
Gardens are at the height of production and food preservation is in high gear. However, many home canners are finding the shelves stripped of canning lids, jars, pectin, vinegar, and the various spices needed for pickling and canning. Even canners, pressure, and water bath, are in short supply. Like all other shortages experienced in this year of COVID-19, it is a matter of supply for an unanticipated demand along with a slow-down in manufacturing due to either worker safety or shortages of raw materials.
Jars. While jars are in demand, canners may be able to find jars in storage among friends and relatives or in second-hand stores. If older canning jars are used, an inspection for nicks, chips, and cracks before buying or using them is a must. A damaged or disfigured jar should never be used for canning food because they are not safe or they could break during processing, wasting time and food. While true canning jars are USDA recommended and preferred, the National Center for Home Food Preservation that commercial glass pint- and quart-size mayonnaise or salad dressing jars may be used with new two-piece lids for canning acid foods (food that might be processed in a boiling water bath). However, one should expect more seal failures and jar breakage. These jars have a narrower sealing surface and are tempered less than Mason jars, and may be weakened by repeated contact with metal spoons or knives used in dispensing mayonnaise or salad dressing. Seemingly insignificant scratches in glass may cause cracking and breakage while processing jars in a canner. Mayonnaise-type jars are not recommended for use with foods to be processed in a pressure canner because of excessive jar breakage. Other commercial jars with mouths that cannot be sealed with two-piece canning lids are not recommended for use in canning any food at home.
Canning lids. Canning lids are designed for one-time use and should not be reused for canning. The sealing compound becomes indented by the first use preventing another airtight seal. Screw bands may be reused unless they are badly rusted or the top edge is pried up which would prevent a proper seal. Previously used canning lids can be used to top jars of freezer jam, homemade mixes, dried goods, and other non-canned foods. As long as the lids aren’t rusty, they’re fine to use again and again for any purpose that doesn’t involve canning. The Jarden (Newell) Company, the manufacturer of Ball products, says that their lids, unused, have a storage life of five years beyond purchase; therefore, if stored lids are in that range, they can be used. Reusable canning lids like those made by Tattler may be a desperate alternative; they have mixed reviews by canners and are not yet recommended by the USDA. (A study on Tattler reusable lids began in 2013 at The National Center for Home Food Preservation. Even with grants received in 2014 and 2015 for the study, it appears that the study is still ongoing as there have been no reported results.) If new lids are not to be found, give consideration to freezing rather than canning.
Canners. Canners are of three types, boiling water bath, pressure, and steam. A boiling water bath canner is a large, deep pot or vessel with a lid and a rack used for high acid food preservation; if a new one can’t be purchased, a second-hand one is fine as long as it isn’t rusty or chipped. A pressure canner is used for low acid foods and is either a weighted gauge or dial gauge type. An older pressure canner may or may not be safe. An older pressure canner should only be purchased or used if it is in excellent condition—no imperfections or warping with a lid that fits perfectly and locks easily. Pressure canners build pressure when they are used, and in extreme cases, could explode if the canner is defective or damaged. More importantly, would be their ability to process food safely. At a minimum, the sealing ring should be replaced and the gauge on a dial gauge type be checked by a trained professional. Dial gauges on pressure canners need to be tested each year against a calibrated ‘master’ gauge. Weighted gauges do not need to be tested as they do not go out of calibration. An atmospheric steam canner is newer to the scene and can take the place of a water-bath canner. According to University of Wisconsin-Madison researchers, steam canners may be used safely to can naturally acid foods such as peaches, pears, and apples, or acidified-foods such as salsa or pickles as long as specified criteria is met; a steam canner is not recommended for low-acid vegetables and meat.
Vinegar. If the recipe does not specify a particular type of vinegar, white or cider vinegar may be used safely as long as it is labeled as 5% acidity or labeled as 50 grain. Apple cider vinegar will impart a different flavor and color when substituted for white vinegar. Specialty vinegars such as red or white wine vinegar, malt vinegar, balsamic, and other flavored vinegars should only be used when specified in a research-tested recipe.
Assorted Pickling Spices. It may not be necessary to get fresh seeds and spices if there is some on your shelf. Commercially prepared and packaged spices, stored properly, such as mustard seed, celery seed, dill seed, allspice, and cinnamon sticks, generally have a shelf life of 3-4 years. Pickling spice is good for up to 3 years. Spices do lose potency over time. To test whether a spice is still potent enough to be effective, rub or crush a small amount in your hand, then taste and smell it. If the aroma is weak and the flavor is not obvious, the spice should not be used as it will not flavor as intended. Spices may be available from online sites when no longer available in local stores.
The right equipment (and vinegar) is a must to safely preserve food by canning. Look to friends and family, online and non-conventional sources for help with acquiring supplies and equipment. Whatever is found, do carefully follow the suggestions contained herein to preserve safely.
“Article used with permission from Iowa State University Extension and Outreach’s AnswerLine.”